49 cat.8100h conductive polymer aluminum solid electrolytic capacitors pcv chip type, high voltage / long life specifications temperature characteristics (max.impedance ratio) category temperature range rated voltage range rated capacitance range capacitance tolerance tangent of loss angle (tan ) esr ( 1) leakage current ( 2) performance characteristics item C 55 to +105c 16 to 125v 5.6 to 680f 20% at 120hz, 20c less than or equal to the specified value at 120hz, 20c less than or equal to the specified value at 100khz, 20c less than or equal to the specified value . after 2 minutes' application of rated voltage at 20c z+105c / z+20c 1.25 (100khz) z C 55c / z+20c 1.25 endurance damp heat (steady state) resistance to soldering heat marking the specifications listed at right shall be met when the capacitors are restored to 20 c after the rated voltage is applied for 3000 hours at 105c. the specifications listed at right shall be met when the capacitors are restored to 20 c after the rated voltage is applied for 1000 hours at 60c, 90% rh. after soldering the capacitor under the soldering conditions prescribed here, the capacitor shall meet the specifications listed at right. pre-heating shall be done at 150 to 200c and for 60 to 180 sec. the duration for over +230c temperature at capacitor surface shall not exceed 60 seconds. in case peak temperature is 250c or less, reflow soldering shall be two times maximum. in case peak temperature is 260c or less, reflow soldering shall be once. measurement for solder temperature profile shall be made at the capacitor top and the terminal. navy blue print on the case top capacitance change tan leakage current ( 2) esr ( 1) within 20% of the initial capacitance value ( 3) 150% or less than the initial specified value 150% or less than the initial specified value less than or equal to the initial specified value capacitance change tan leakage current ( 2) esr ( 1) within 20% of the initial capacitance value ( 3) 150% or less than the initial specified value 150% or less than the initial specified value less than or equal to the initial specified value capacitance change tan leakage current ( 2) esr ( 1) within 10% of the initial capacitance value ( 3) 130% or less than the initial specified value 130% or less than the initial specified value less than or equal to the initial specified value high voltage (to 125v), low esr, high ripple current. load life of 3000 hours at 105c. smd type : lead free reflow soldering condition at 260c peak correspondence. compliant to the rohs directive (2011/65/eu). aec-q200 compliant. please contact us for details. 1 esr should be measured at both of the terminal ends closest where the terminals protrude through the plastic platform. 2 conditioning : if any doubt arises, measure the leakage current after the voltage treatment of applying dc rated voltage continuously to the capacitor for 120 minutes at 105c. 3 initial value : the value before test of examination of resistance to soldering. p 1 c 2 v 3 1 4 v 5 8 6 2 7 0 8 m 9 c 10 l 11 1 12 g 13 s 14 configuration t aping code siz e code capacitance toler ance ( 20%) rated capacitance ( 82f ) rated v oltage ( 35v ) ser ies name t ype c v 8 2 v 0 1 2 h 0.3 m ax. d0.5 b 0.2 a 0.2 c 0.2 0.5 m ax. e l series voltage (v:35v) plastic platform lot no. capacitance negative positive +0.1 - 0 .4 dimensions type numbering system (example : 35v 82f) dimension table in next page. d l a b c e h 6.3 5.9 7.3 6.6 6.6 2.1 0.5 to 0.8 size 6.3 6l 8.0 6.9 9.0 8.3 8.3 3.2 0.8 to 1.1 8 7l 8.0 9.9 9.0 8.3 8.3 3.2 0.8 to 1.1 8 10l 8.0 11 .9 9.0 8.3 8.3 3.2 0.8 to 1.1 8 12l 10.0 7.9 11 .0 10.3 10.3 4.6 0.8 to 1.1 10 8l 10.0 9.9 11 .0 10.3 10.3 4.6 0.8 to 1.1 10 10l 10.0 12.6 11 .0 10.3 10.3 4.6 0.8 to 1.1 10 12.7l (mm) code c v 16 d 20 e 25 v 35 h 50 j 63 k 80 2a 100 2b 125 v oltage pcv high temperature pcx frequency coefficient of rated ripple current 0 frequency 0/ coefficient 120hz 1khz 10khz 100khz or more 0.05 0.30 0.70 1.00
50 cat.8100h conductive polymer aluminum solid electrolytic capacitors pcv dimensions rated voltage (v)(code) surge voltage (v) esr (m ) (at 100khz 20c) rated ripple (marms) rated capacitance (f) case size d l (mm) tan part number leakage current (a) 1000 1300 1500 1700 2000 2000 3800 2300 3200 2400 4100 3900 2800 4400 1000 1300 1300 1400 2000 1900 3100 3700 2300 4000 2300 3800 2700 4300 1000 1300 1300 1400 1900 1800 3600 2200 3000 2300 3800 3700 2700 4200 900 1300 1200 1400 1900 1800 3600 2200 3000 2200 3800 3700 2600 4100 ?50 47 ?36 34 ?27 31 21 ?26 24 ?26 20 21 ?25 19 ?55 48 ?45 42 ?28 33 25 22 ?27 21 ??27 22 ?26 20 ?60 49 ?50 47 ?29 35 23 ?28 26 ??28 22 23 ?27 21 64 50 ?55 52 ?31 37 24 ?29 27 ??29 23 24 ?28 22 179 262 320 480 704 704 864 864 864 1056 1248 1504 1504 2176 188 224 272 400 600 600 720 880 880 1080 1080 1320 1320 1880 165 235 280 410 600 600 750 750 750 900 1100 1350 1350 1950 126 154 189 273 392 476 574 574 574 700 840 840 1050 1260 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 6. 3 6 6. 3 6 8 7 8 7 8 10 10 8 8 10 8 12 10 8 10 10 8 12 10 10 10 12.7 10 12.7 6. 3 6 6. 3 6 8 7 8 7 8 10 10 8 10 8 8 10 8 12 8 12 10 10 10 10 10 12.7 10 12.7 6.3 6 6.3 6 8 7 8 7 8 10 10 8 8 10 8 12 10 8 10 10 8 12 10 10 10 12.7 10 12.7 6. 3 6 6. 3 6 8 7 8 7 8 10 10 8 8 10 8 12 10 8 10 10 8 12 10 10 10 12.7 10 12.7 56 82 100 150 220 220 270 270 270 330 390 470 470 680 47 56 68 100 150 150 180 220 220 270 270 330 330 470 33 47 56 82 120 120 150 150 150 180 220 270 270 390 18 22 27 39 56 68 82 82 82 100 120 120 150 180 18.4 28.7 23.0 16 (1c) 20 (1d) 25 (1e) pcv1c560mcl1gs pcv1c820mcl2gs pcv1c101mcl1gs pcv1c151mcl2gs pcv1c221mcl6gs pcv1c221mcl1gs pcv1c271mcl7gs pcv1c271mcl1gs pcv1c271mcl2gs pcv1c331mcl1gs pcv1c391mcl2gs pcv1c471mcl2gs pcv1c471mcl1gs pcv1c681mcl2gs pcv1d470mcl1gs pcv1d560mcl2gs pcv1d680mcl1gs pcv1d101mcl2gs pcv1d151mcl6gs pcv1d151mcl1gs pcv1d181mcl2gs pcv1d221mcl7gs pcv1d221mcl1gs pcv1d271mcl2gs pcv1d271mcl1gs pcv1d331mcl2gs pcv1d331mcl1gs pcv1d471mcl2gs pcv1e330mcl1gs pcv1e470mcl2gs pcv1e560mcl1gs pcv1e820mcl2gs pcv1e121mcl6gs pcv1e121mcl1gs pcv1e151mcl7gs pcv1e151mcl1gs pcv1e151mcl2gs pcv1e181mcl1gs pcv1e221mcl2gs pcv1e271mcl2gs pcv1e271mcl1gs pcv1e391mcl2gs pcv1v180mcl1gs pcv1v220mcl2gs pcv1v270mcl1gs pcv1v390mcl2gs pcv1v560mcl1gs pcv1v680mcl1gs pcv1v820mcl7gs pcv1v820mcl1gs pcv1v820mcl2gs pcv1v101mcl1gs pcv1v121mcl7gs pcv1v121mcl2gs pcv1v151mcl1gs pcv1v181mcl2gs 40.2 35 (1v)
51 cat.8100h conductive polymer aluminum solid electrolytic capacitors pcv dimensions taping specifications are given in page 23. recommended land size, soldering by reflow are given in page 18, 19. please refer to page 3 for the minimum order quantity. rated voltage (v)(code) surge voltage (v) esr (m ) (at 100khz 20c) rated ripple (marms) rated capacitance (f) case size d l (mm) tan part number leakage current (a) 800 1200 1100 1300 1700 1500 2000 3300 2600 2200 3400 3400 2600 3600 700 1200 1000 1100 1700 1400 3200 2000 2500 2200 3400 3300 2500 3400 1600 1800 1900 2200 1500 1700 1900 2100 1100 1300 1400 2000 ???81 55 ?63 60 ?36 49 ?34 29 37 ??30 28 29 ?29 27 105 56 ?75 70 ?37 56 30 ?35 38 ??31 29 30 ?30 28 43 41 39 38 48 45 42 41 93 84 69 48 82 120 150 220 330 330 390 470 470 470 560 680 680 1000 71 103 126 151 277 277 340 340 340 416 491 592 592 706 160 192 240 352 136 200 240 360 170 205 300 375 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 0.12 6.3 6 6.3 6 8 7 8 7 8 10 10 8 8 12 8 10 10 8 10 10 8 12 10 10 10 12.7 10 12.7 6.3 6 6.3 6 8 7 8 7 8 10 10 8 8 10 8 12 10 8 10 10 8 12 10 10 10 12.7 10 12.7 8 10 8 12 10 10 10 12.7 8 10 8 12 10 10 10 12.7 8 10 8 12 10 10 10 12.7 8.2 12 15 22 33 33 39 47 47 47 56 68 68 100 5.6 8.2 10 12 22 22 27 27 27 33 39 47 47 56 10 12 15 22 10 12 18 12 15 57.5 72.4 92.0 50 (1h) 63 (1j) 80 (1k) 115 100 (2a) 143 125 (2b) pcv1h8r2mcl1gs pcv1h120mcl2gs pcv1h150mcl1gs pcv1h220mcl2gs pcv1h330mcl6gs pcv1h330mcl1gs pcv1h390mcl1gs pcv1h470mcl7gs pcv1h470mcl2gs pcv1h470mcl1gs pcv1h560mcl2gs pcv1h680mcl2gs pcv1h680mcl1gs PCV1H101MCL2GS pcv1j5r6mcl1gs pcv1j8r2mcl2gs pcv1j100mcl1gs pcv1j120mcl2gs pcv1j220mcl6gs pcv1j220mcl1gs pcv1j270mcl7gs pcv1j270mcl1gs pcv1j270mcl2gs pcv1j330mcl1gs pcv1j390mcl2gs pcv1j470mcl2gs pcv1j470mcl1gs pcv1j560mcl2gs pcv1k100mcl1gs pcv1k120mcl1gs pcv1k150mcl1gs pcv1k220mcl1gs pcv2a6r8mcl1gs pcv2a100mcl1gs pcv2a120mcl1gs pcv2a180mcl1gs pcv2b6r8mcl1gs pcv2b8r2mcl1gs pcv2b120mcl1gs pcv2b150mcl1gs 6.8 6.8 8.2 rated ripple current (marms) at 105c 100khz no marked, 1 will be put at 12th digit of type numbering system. : in this case, 2 will be put at 12th digit of type numbering system. : in this case, 6 will be put at 12th digit of type numbering system. : in this case, 7 will be put at 12th digit of type numbering system.
|
